Alternative Technologies For The Destruction Of Chemical Agents And Munitions

The U.S. Army Chemical Stockpile Disposal Program was established with the goal of destroying the nation's stockpile of lethal unitary chemical weapons. Since 1990 the U.S. Army has been testing a baseline incineration technology on Johnston Island in the southern Pacific Ocean. Under the planned disposal program, this baseline technology will be imported in the mid to late 1990s to continental United States disposal facilities; construction will include eight stockpile storage sites. In early 1992 the Committee on Alternative Chemical Demilitarization Technologies was formed by the National Research Council to investigate potential alternatives to the baseline technology. This book, the result of its investigation, addresses the use of alternative destruction technologies to replace, partly or wholly, or to be used in addition to the baseline technology. The book considers principal technologies that might be applied to the disposal program, strategies that might be used to manage the stockpile, and combinations of technologies that might be employed.

The U.S. Army Chemical Stockpile Disposal Program was established with the goal of destroying the nation's stockpile of lethal unitary chemical weapons. Since 1990 the U.S. Army has been testing a baseline incineration technology on Johnston Island in the southern Pacific Ocean. Under the planned disposal program, this baseline technology will be imported in the mid to late 1990s to continental United States disposal facilities; construction will include eight stockpile storage sites. In early 1992 the Committee on Alternative Chemical Demilitarization Technologies was formed by the National Research Council to investigate potential alternatives to the baseline technology. This book, the result of its investigation, addresses the use of alternative destruction technologies to replace, partly or wholly, or to be used in addition to the baseline technology. The book considers principal technologies that might be applied to the disposal program, strategies that might be used to manage the stockpile, and combinations of technologies that might be employed.

This report examines seven disposal technologies being considered by the U.S. government as alternative methods to the process of incineration for destroying mortars, rockets, land mines, and other weapons that contain chemical warfare agents, such as mustard gas. These weapons are considered especially dangerous because they contain both chemical warfare agent and explosive materials in an assembled package that must be disassembled for destruction. The study identifies the strengths and weaknesses and advantages and disadvantages of each technology and assesses their potential for full-scale implementation.

Chemical warfare materiel (CWM) encompasses diverse items that were used during 60 years of efforts by the United States to develop a capability for conducting chemical warfare. Non-Stockpile CWM (NSCWM) is materiel not included in the current U.S. inventory of chemical munitions and includes buried materiel, recovered materiel, components of binary chemical weapons, former production facilities, and miscellaneous materiel. Because NSCWM is stored or buried at many locations, the Army is developing transportable treatment systems that can be moved from site to site as needed. Originally, the Army planned to develop three transportable treatment systems for nonstockpile chemical materiel: the rapid response system (RRS), the munitions management device (MMD), and the explosive destruction system (EDS). This report supplements an earlier report that evaluated eight alternative technologies for destruction of the liquid waste streams from two of the U.S. Army's transportable treatment systems for nonstockpile chemical materiel: the RRS and the MMD. This report evaluates the same technologies for the destruction of liquid waste streams produced by the EDS and discusses the regulatory approval issues and obstacles for the combined use of the EDS and the alternative technologies that treat the EDS secondary waste streams. Although it focuses on the destruction of EDS neutralent, it also takes into consideration the ability of posttreatment technologies to process the more dilute water rinses that are used in the EDS following treatment with a reagent.

By direction of Congress, the U.S. Department of Defense's (DoD's) program manager for the Assembled Chemical Weapons Assessment (PMACWA) asked the National Research Council (NRC) Committee on Review and Evaluation of Alternative Technologies for Demilitarization of Assembled Chemical Weapons: Phase II (the ACW II committee) to conduct an independent scientific and technical assessment of three alternative technologies (referred to as Demo II) under consideration for the destruction of assembled chemical weapons at U.S. chemical weapons storage sites. The three technologies are AEA Technologies Corporation's (AEA's) electrochemical oxidation process; the transpiring-wall supercritical water oxidation and gasphase chemical reduction processes of Foster Wheeler/Eco Logic/Kvaerner (FW/EL/K); and Teledyne-Commodore's solvated electron process. Each of these technologies represents an alternative to incineration for the complete destruction of chemical agents and associated energetic materials. The demonstration tests were approved by the PMACWA after an initial assessment of each technology. The results of that initial assessment were reviewed by an earlier NRC committee, the Committee on Review and Evaluation of Alternative Technologies for Demilitarization of Assembled Chemical Weapons (the ACW I committee). For the present review, the committee conducted an indepth examination of each technology provider's data, analyses, and demonstration test results for the critical components tested. This review report supplements the ACW I report and considers the demonstration performance of the Demo II candidate technologies and their readiness for advancement to pilot-scale implementation. Because testing in these areas is ongoing, the committee decided to cut short its fact-finding efforts for input to this report as of March 30, 2001.

In 1996, the U.S. Congress enacted two laws, Public Law 104-201 (authorization legislation) and Public Law 104-208 (appropriation legislation), mandating that the U.S. Department of Defense (DOD) conduct an assessment of alternative technologies to the baseline incineration process for the demilitarization of assembled chemical munitions. The PMACWA had previously requested that the National Research Council (NRC) perform and publish an independent evaluation of the seven technologies packages that had been selected during earlier phases of the Assembled Chemical Weapons Assessment (ACWA) program and deliver a report by September 1, 1999. However, to meet that deadline, the NRC Committee on Review and Evaluation of Alternative Technologies for Demilitarization of Assembled Chemical Weapons (ACW Committee) had to terminate its data-gathering activities on March 15, 1999, prior to the completion of demonstration tests. In September 1999, the PMACWA requested that the ACW Committee examine the reports of the demonstration tests and determine if the results changed the committee's original findings, recommendations, and comments. Evaluation of Demonstration Test Results of Alternative Technologies for Demilitarization of Assembled Chemical Weapons documents the committee's reassessment of the findings and recommendations in the original report, Review and Evaluation of Alternative Technologies for Demilitarization of Assembled Chemical Weapons.

The Chemical Weapons Convention requires, among other things, that the signatories to the conventionâ€"which includes the United Statesâ€"destroy by April 29, 2007, or as soon possible thereafter, any chemical warfare materiel that has been recovered from sites where it has been buried once discovered. For several years the United States and several other countries have been developing and using technologies to dispose of this non-stockpile materiel. To determine whether international efforts have resulted in technologies that would benefit the U.S. program, the U.S. Army asked the NRC to evaluate and compare such technologies to those now used by the United States. This book presents a discussion of factors used in the evaluations, summaries of evaluations of several promising international technologies for processing munitions and for agent-only processing, and summaries of other technologies that are less likely to be of benefit to the U.S. program at this time.